随着洁净室的诞生，手套就在洁净服装系统中扮演着一个重要角色，它不但应有充分的防护作用，而且不应向受控环境扩散微粒。以前人们往往将手套使用一次就扔掉，这样不但成本高，而且也不利于环保。现在越来越多的工厂趋向于使用再生手套，就是将使用过的手套送交专业清洗公司进行洁净清洗后再次使用。由于丁腈手套有优良的洁净性能、防静电性能和机械性能，特别适合再生清洗。

 

With the birth of the clean room, the gloves are playing an important role in the clean clothing system, which not only should have full protective effect, but also should not be controlled by the environment. In the past, people used to throw away the gloves once, so that not only high cost, but also not conducive to environmental protection. Now more and more factories tend to use recycled gloves, which will be used in the use of gloves to professional cleaning company for the use of clean. The nitrile gloves clean performance, excellent antistatic properties and mechanical properties, especially suitable for cleaning and regeneration.

 

但是，在手套的再生清洗中，一般是采用非离子中性表面清洗剂进行清洗，离子及灰尘、污渍等污染物较易去除，而来自于人体本身及所使用的护肤品中的硅油却不是那么容易去掉而成为一个非常棘手的问题。

 

However, the use of non ion neutral cleaning agent for cleaning, ion and dust, stains and other pollutants are more easily removed, and from the human body itself and the use of skin care products in the silicone oil is not so easy to remove and become a difficult problem.

 

一般来说，手套硅油产生的原因有如下几个：

 

Generally speaking, there are several reasons for the production of silicone oil:

 

1）季节差异造成：春夏季节，手套硅油问题几乎不存在，因为天气温暖湿润，人 们不需要涂抹护肤品也能使皮肤保持湿润、光泽、有弹性；而秋冬季节，气候干燥寒冷、爱美的姑娘们往脸上、嘴上、手上搽上脸霜、唇膏和手霜，防止皮肤干燥开裂，手套硅油问题就日益突出。

 

1) seasonal differences in the summer season, the problem is almost non-existent, because the weather is warm and humid, people do not need to apply skin care products can also make the skin moist, shiny, elastic; autumn and winter season, the climate is dry cold, beauty girls face, mouth, hand on the face cream, lipstick and hand cream to prevent dry skin cracking, gloves, silicone oil is increasingly prominent.

 

2）工序操作中产生：有些工序机台含有硅油制剂，操作时人员手套接触而污染。

 

2) operation of the process: some of the process machine contains silicone oil preparation, the operation of personnel gloves contact and pollution.

 

3）材质本身含有硅油：由于材质本身缺陷造成。

 

3) the material itself contains silicone oil: due to the material itself defects caused.

 

上述两项产生的硅油，可通过正确清洗除去，但第三项的硅油仅靠清洗是无法去除的。

 

The above two of the production of silicone oil, can be removed by proper cleaning, but third of the silicone oil can not be removed by cleaning.

 

如何在清洗中有效去除手套硅油？净化铝材配件 http://www.jnjkjh.com/ 小编建议从以下几方面综合考虑：

 

How to remove the gloves and silicone oil effectively in the wash? Purification of aluminum parts of the small series of suggestions from the following several aspects:

 

1）清洗溶剂：要选用专用去油的非离子中性表面清洗剂；

 

1) cleaning solvent: non ion neutral surface cleaning agent to use special oil;

 

2）溶剂配比浓度：合适的浓度可以使去硅油效果达到最佳；应根据具体溶剂而定。

 

2) the concentration of the solvent concentration: the suitable concentration can make the effect of the silicone oil to reach the best.

 

3）溶剂清洗温度：合适的温度可使溶剂发挥最大清洁效能；以45-50℃为宜。

 

3) solvent cleaning temperature: the suitable temperature can make the solvent play the maximum cleaning efficiency; the 45-50 is appropriate.

 

4）溶剂清洗时间：时间不宜过短，否则溶剂不能与硅油很好地亲合而影响清洗效果。一般至少要30分钟。

 

4) solvent cleaning time: time is not too short, otherwise the solvent can not be very good with silicone oil and the effect of cleaning. At least 30 minutes.

 

5）漂洗水质：建议用RO/DI水，防止交叉污染。特别是最后几道漂洗工序，一定要用DI水，否则清洁度无法保证。

 

5) rinse water quality: it is recommended to use RO/DI water to prevent cross contamination. Especially in the last several rinsing process, be sure to use DI water, or clean degree can not guarantee.

 

6）漂洗温度：一定的温度能更好地使残留硅油从手套表面上析出。

 

6) rinse temperature: a certain temperature can better make the residual oil from the glove surface precipitation.

 

7）漂洗时间/次数：每次漂洗时间5-10分钟左右为宜，次数不少于5次。

 

7) rinse time / Number: 5-10 minutes per rinse is appropriate, the number is not less than 5 times.

 

8）烘干机清洁：每次烘干手套前，应用无尘布沾溶剂擦拭烘干机内壁，以免交叉污染。

 

8) drying machine cleaning: every time before drying gloves, application of dust cloth with solvent wipe the inner wall of the dryer, so as to avoid cross contamination.

 

总之，将手套硅油清洗干净不是件容易的事，需要我们不断地实验、实验、再实验，才能找出一个最佳清洗方案。鉴于硅油清洗的难度如此之大，我们建议在使用手套时应采取一些预防措施以将硅油污染减至最少，如：洁净室工作人员不允许化妆；进洁净室之前，应将脸部及手部彻底清洗干净；含硅油制剂不允许在洁净室内使用等。

 

In short, it is not easy to clean the gloves and silicone oil, we need to continue to experiment, experiment, and then experiment, to find out a best cleaning solution. In view of the difficulty of silicone oil cleaning is so large, we recommend that before in gloves should take some preventive measures to silicone oil pollution to a minimum, such as: clean room staff not allowed to make-up; into the cleanroom, should be the face and hands are thoroughly cleaned; containing silicone oil formulation does not allow for in clean indoor use.